Tips for the Winter Storage of Your Electric Golf Cart

November 6, 2009

FREE PRIVATE PLAYERS PICKS OF THE DAY- CALL 516-852-4502- I WILL WIN YOU MONEY STARTING TODAY...

It’s very important to know how to properly store your electric golf cart during Winter. Here are some tips for the proper storage of your electric golf cart:

First of all you should clean your golf cart batteries and ensure that all the cell caps are snugly attached. Then unplug the charger and wash the battery compartment. Spray Battery Neutralizer all over the tops of the batteries by starting on one side of the golf cart. Be sure to spray between the batteries, down on the battery racks, and the inside walls of the body panels, if they are metal. Use an old paintbrush to scour all the battery tops and sides. Water from a garden hose using plain water, or use a solution of Baking Soda (about 2 tablespoons to 1 gallon of water) to neutralize the acid.

Clean, tighten, check and treat all of the battery terminal connections. Be sure the cables are tight to the post. Carefully wriggle each cable end side-to-side and then gently up & down. There should be no looseness or sideways movement. You will need to do some serious cleaning, if your battery terminals are badly corroded.

Check the water levels in each cell. Be sure the electrolyte (water) in each battery cell is above the plates and use distilled water. In cold climates, when the cart will be left uncharged for several months, leave the water level a little low. This raises the specific gravity of the acid, which will help prevent freezing. A lead acid battery keeps much better in the cold than in the heat, as long as the charge stays up.

A fully charged battery will not freeze until 60 to 70 below zero whereas a discharged battery can freeze at 20 degrees above zero. As a battery discharges, the acid turns into water by the basic chemical nature of the lead acid battery. The more discharge, the more water and the more likely it is to freeze. Also a dirty, acid covered battery will self-discharge at a faster rate than a clean treated battery, even in cooler temperatures.

Don’t leave your electric golf cart plugged into the charger for extended periods of time. After the charge is done, unplug the charger from the cart and from the wall.

Turn the key off and leave the cart in neutral. Either way, scotch the wheels so you can leave the hill brake released. This prevents strain on the cables and the brake shoes can’t lock to the drums.

You can plug your Charger in for a few hours once a month to insure a full charge is maintained If you are not going away for the winter. The charger should be unplugged from the car and the wall after charging.

Finalize for winter storage by checking the tire pressures and inflate to 20-25 psi.

Roll down the rain curtains and zip them part way down. If you have to leave the car out in the open, or under an open shed, neatly fold the rain curtain and bring it in the house till spring. Very cold weather will cause the see through vinyl to become very brittle and a puff of wind will blow it out.

For additional information on electric golf cart batteries including how lead acid batteries work; charging batteries; how to use a hydrometer and troubleshooting golf cart batteries, please visit:

The Electric Golf Cart Battery Guide

 

 

 

 


CALL 516-852-4502 If you are serious about making MONEY....


Comments

Comments are closed.